设为首页 | 加入收藏

ddd

新闻中心

手机:
(0)13771026479

 

地址:
江苏无锡市新区新世界国际B-14幢

 

新闻中心 您当前所在的位置: 首页>>新闻中心

环氧地坪施工基础处理

作者:匿名    访问量:3124    发布时间:2013/12/26

本文由无锡奥科涂装工程有限公司提供,更多环氧地坪漆资讯请访问www.psdang.com

 

1、用研磨机进行全面打磨。让破损、起沙、粘度不牢、开裂、空鼓之部位完全暴露出来;并将浮起的砂浆、旧环氧水泥结块等打磨平整。
2、有松动、裂缝或脱层的地面,必须彻底打磨至密实基层,保证地面的粘结度
3、将基层表面的浮灰、污染物等垃圾清理干净,确保基层表面的干净度。
4、将处过的地面清洁。
检验方法:经处理后,地坪表面平整、密实、干燥,无油污、且没有松动易碎颗粒,方可进行下一工序施工。
伸缩缝、裂缝、空鼓地面、松动旧环氧的特殊处理
1、对开裂之部位采用切割片切成V型小槽后,再用高倍中涂砂浆予以修补填平;细小的裂缝可以用环氧树脂加Extender T增稠剂修补;待完全固化后再用手磨机细打至平整。
2、对空鼓、旧环氧松动之部位凿除,如凹糟较深,采用高倍中涂砂浆予以补平,完全固化后再用手磨机细打至平整。
3、所有特殊场地修补处理后,再清洁一遍。
检验方法:
a、以上部位的处理是整个环氧地坪使用寿命长短的重要一环,不然将导致地坪开裂。


b、经处理后,与整个地面相平,修补处无离间、密实,坚硬,平整。

1, with a comprehensive polishing grinder.Let damaged, sand, viscosity, cracking, empty drum position fully exposed;And will float old epoxy mortar, cement agglomeration, burnish is flat and level.2, loose, cracks or take off a layer of floor, must be thoroughly polished to dense grassroots, guarantee the bonding of the ground3, will float on the surface of the base grey, pollutants, such as clean up garbage, to ensure that the clean degree of the basic surface.4, will place the ground clean.Test method: after processing, floor surface smooth, dense, dry, no oil, loose and not brittle particles, can on to the next working procedure construction.Expansion joints, cracks, empty drum of ground, loose old epoxy special treatmentIs used for the cracking of the part 1, cutting slices cut into small V groove, further repair mortar with high power of bridge;Tiny cracks can add Extender with epoxy resin T thickener mended;After being cured reoccupy hand mill fine until smooth.2, the empty drum, old place chisel except of epoxy loose, such as concave worse is deeper, USES the high power coating mortar shall fill in the flat, reoccupy after complete curing hand mill fine until smooth.3, all special field repair processing, clean it again.Test method:A, the above parts processing is an important component of the whole floor use lifespan otherwise will result in the crack of the floor.B, after processing, and the ground is flat, mend without alienating, dense, stiff, flat and level.

 

博亿堂国际-博亿堂娱乐在线-博亿堂手机版